Home

RUSTECO R-200-3
RUSTECO GEL
GREASEMASTER R-300
SDS



Safety Data Sheet Issue Date: March 11, 2020
Identity: (As used on label and list)
RUSTECO GreaseMaster
Printable PDF of Safety Data Sheet

SECTION 1: Material & Manufacturer Identification

Product Name RUSTECO GreaseMaster
Material Type LIQUID
Product Use Surface Cleaning Detergent, Corrosion Treatment
Manufacturer Address RUSTECO
P.O Box 11398,
Torrance, CA 90510
Emergency Phone 800-787-8326
Fax 310-294-9635
E-mail rusteco@aol.com

SECTION 2: Hazards Identification

2.1 Classification of the substance or mixture
GHS Class Skin corrosion/irritation, Category 3
Skin sensitization, Category 1B
Eye Irritation, Category 2B
Acute toxicity Oral, Category 4

Classification Classification according to Regulation (EC) No 1272/2008
Based on present data no classification and labeling is required according to Directive 1272/2008/EC and its amendments (CLP Regulation, GHS).

Classification according to Directive 67/548/EEC or Directive 1999/45/EC
According to present data no classification and labeling is required according to Directives 67/548/EEC or 1999/45/EC.

2.2 GHS Label elements, including precautionary statements

GHS Pictorgrams
Signal Word Warning
Hazard Statements H302 – Harmful if swallowed
H316 – Causes mild skin irritation
H317 – May cause an allergic skin reaction
H320 – Causes eye irritation
Precautionary Statements P261 – Avoid breathing fume, misty, spray, vapors.
P264 – Wash hands thoroughly after handling. P270 – Do not eat, drink or smoke when using this product
P280 – Wear eye protection, protective clothing, protective gloves
P301 + P310 + P331 – IF SWALLOWED: Immediately call a poison center/doctor.
P303 + P361 + P353 + P314 – IF ON SKIN: Take off immediately all contaminate clothing. Rinse skin with water/shower. Get medical attention if you feel unwell.
P305 + P351 + P338 + P314 – IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do so. Continue rinsing. Get medical attention if you feel unwell

2.3 Hazards not otherwise classified (HNOC) or not covered by GHS - None


SECTION 3: Composition/Information on Ingredients

3.1 Product Mixture
Synonyms
Formula
Molecular wt
CAS-No.
EC-No.
No Data Available
No data available; mixture
Mixture
Mixture
Mixture

Chemical Name

CAS-No.

Ingredient Percent

Water

Alkyl Polyglucoside, non-ionic surfactant Citric Acid

Sodium Gluconate

7732-18-5

68515-73-81

77-92-9

527-07-1

89.75%

7.4%

2.6%

0.25%

Remarks There are no additional hazardous ingredients greater than or equal to 1.0 wt% concentration or carcinogenic ingredients greater than or equal to 0.1 wt% concentration.

SECTION 4: First Aid Measures

4.1 Description of First Aid Measures
General advice

Consult a physician. Show this safety data sheet to the doctor in attendance.
Skin contact Wash off with a disinfectant soap and water. Consult a physician if symptoms occur.
Eye contact Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician if symptoms occur.
Inhalation In case of difficult breathing, move person to fresh air. Consult a physician if symptoms occur.
Indigestion Rinse mouth. Immediately dilute by drinking large amounts of water. After dilution induce vomiting. Get immediate medical advice/attention.
4.2 Most important symptoms and effects, both acute and delayed
Symptoms and effects

The most important known symptoms and effects are described in the labelling (see section 2.2) and in section 11.
4.3 Indication of any immediate medical attention and special treatment needed
Other first aid No data available

SECTION 5: Fire Fighting Measures

5.1 Suitable (and unsuitable) extinguishing media
Suitable extinguishing media Use water, alcohol-resistant foam, dry chemical or carbon dioxide spraying extinguishing media to base of flames.
5.2 Special hazards arising from the substance or mixture
Special hazards Excessive thermal decomposition at very high temperatures can lead to release of irritating gases and vapors. Keep product and empty container away from heat and sources of ignition.
5.3 Advice for firefighters
Protective equipment Wear self-contained breathing apparatus for firefighting if necessary.

SECTION 6: Accidental Release Measures

6.1 Personal precautions, protective equipment, and emergency procedures
Personal precautions For personal protection see section 8.
6.2 Environmental precautions
Environmental precautions In case of large spills, dike spill to prevent runoff into sewers and drains. Recover as much of the material as possible.
6.3 Methods and materials for containment and cleaning up
Methods for cleanup Soak up with inert absorbent material and dispose. Keep in suitable, closed containers for disposal.
6.4 References to other sections
Other references For disposal see section 13.

SECTION 7: Handling and Storage

7.1 General hygiene considerations
General hygiene Avoid contact with skin and eyes. In case of large quantities of vapor or mist, use local exhaust or general dilution ventilation to control exposure within applicable limits. For precautions see section 2.2.
7.2 Precautions for safe handling
Environmental precautions Keep container tightly closed in a dry and well-ventilated place
7.3 Conditions for safe storage, including any incompatibilities
Methods for cleanup Apart from the uses mentioned in section 1.2 no other specific uses are stipulated

SECTION 8: Exposure Controls/Personal Protection

8.1 Control and exposure limits recommended by the chemical manufacturer
OSHA Standards Not available - not determined
Threshold Limit Values Not available - not determined
NIOSH Recommendations Not available - not determined
8.2 Appropriate engineering controls
Engineering controls Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday. Use adequate ventilation where dust forms to keep concentration under exposure control limits.
8.3 Individual protection measures, such as personal protective equipment
Respiratory protection None required for consumer use. For manufacturing quantities: where risk assessment shows air-purifying respirators are appropriate use a full-face respirator with multipurpose combination (US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-face supplied air respirator. Use respirators and
components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU).
Eye/face protection For manufacturing quantities: safety glasses with side-shields conforming to EN166 are recommended. Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166 (EU).
Hand protection For manufacturing quantities: handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands.
Body protection For manufacturing quantities: wear impervious clothing. The type of protective equipment must be selected according to the concentration and amount of the dangerous substance at the specific workplace.

SECTION 9: Physical and Chemical Properties

9.1 Information on basic physical and chemical properties
a) Appearance Amber Liquid
b) Odor Characteristic
c) Odor threshold No data available
d) pH (1% solution) 5 - 6
e) Melting/freezing point No data available
f) Boiling point 220oF
g) Flash point N/A
h) Evaporation rate No data available
i) Flammability (solid, gas) No data available
j) Upper/lower flammability or explosive limits Upper (UEL): No data available
k) Vapor pressure Lower (LEL): No data available
l) Vapor density No data available
m) Relative density No data available
n) Water solubility 1.04
o) Partition coefficient octanol/water No data available
p) Auto-ignition temp No data available
q) Decomposition temp No data available
r) Viscosity No data available

SECTION 10: Stability and Reactivity

10.1 Reactivity
Reactivity No significant reactivity hazards.
10.2 Chemical stability
Chemical stability Stable under ordinary conditions of use and storage.
10.3 Possiblity of hazardous reactions
hazardous reactions No data available
10.4 Conditions to avoid
Conditions to avoid Excess heat. Contact with strong acids, alkali or oxidizing agents.
10.5 Incompatible materials
Incompatible materials Strong acids, alkali or oxidizing agents.
10.6 Hazardous decomposition products
Hazardous products Thermal degradation may produce oxides of carbon and/or nitrogen and/or derivatives.

SECTION 11: Toxicological Information

11.1 Information on toxicological effets
Acute toxicity
Acute oral toxicity LD50 (Rat) 1.26 g/kg
Acute dermal toxicity Skin PIS (rabbit) Moderate
Acute inhalation toxicity No data available
Skin corrosion/irritation
Skin corrosion irritation Causes mild skin irritation
Serious eye damage/eye irritation
Eye damage/eye irritation Causes eye irritation
Respiratory or skin sensitization
Respiratory sensitizer No data available
Skin sensitizer May cause an allergic skin reaction
Germ cell mutagenicity
Mutagenicity No data available
Suspected cancer agent
ACGIH No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen.
NTP No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen.
OSHA No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen.
IARC No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen.
Reproductive toxicity
Reproductive toxicity This product is not reported to produce mutagenic, embryotoxic, teratogenic, or reproductive effects in humans.
Aspiration hazard
Aspiration hazard No data available

SECTION 12: Ecological Information

12.1 Ecotoxicity (aquatic and terrestrial)
Ecotoxicity No data available
12.2 Persistence and degradability
Degradability Biodegradable
12.3 Bioaccumulation potential
Bioaccumulation No data available
12.4 Mobility in soil
Mobility in soil No data available
12.5 Results of PBT and vPvB assessment
PBT/vPvB assessment Not available as chemical safety assessment not required/not conducted.

SECTION 13: Disposal Considerations

13.1 Waste treatment methods
Waste treatment disposal Waste disposal must be in accordance with appropriate Federal, State, and local regulations. This product, if unaltered by use, may be disposed of by treatment at a permitted facility or as advised by your local hazardous waste regulatory authority.

SECTION 14: Transport Information

DOT Not dangerous goods.
TDG Not dangerous goods.
IMDG Not dangerous goods.
IATA Not dangerous goods.

SECTION 15: Regulatory Information

15.1 Safety, health, and environmental regulations specific to the product or mixture
SARA 302 Components No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302.
SARA 313 Components This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313.
TSCA This product contains the following chemical substances subject to the reporting requirements of
TSCA 12(b) if exported from the United States: None
EINECS All components of this product are on the European Inventory of Existing Commercial Chemical Substances.
Canada DSL All components of this product are on the Canada Domestic Substance List.
CA Prop. 65 Components This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm.

SECTION 16: Other Information

HMIS Rating Health hazard: 1
Flammability: 0
Physical Hazard: 0
NFPA Rating Health hazard: 1
Fire Hazard: 0
Reactivity Hazard: 0
Revision Date 11 March 2020
The information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of these data or the results to be obtained from the use thereof. RUSTECO assumes no responsibility for injury to the vendee or third persons proximately caused by the material if reasonable safety procedures are not adhered to as stipulated in the data sheet. Additionally, RUSTECO assumes no responsibility for injury to vendee or third persons proximately caused by use of the material even if reasonable safety procedures are followed. Furthermore, vendee assumes the risk in his use of the material.
Abbreviations and acronyms IMDG - International Maritime Code for Dangerous Goods
TDG - Transportation of Dangerous Goods
IATA - International Air Transport Association
GHS - Globally Harmonized System of Classification and Labelling of Chemicals
PBT - Persistent, bioaccumulative and toxic assessment
vPvB - Very persistent and very bioaccumulative assessment
ACGIH - American Conference of Governmental Industrial Hygienists
NIOSH - National Institute for Occupational Safety and Health
TLV - Threshold Limit Values
CAS - Chemical Abstracts Service (division of the American Chemical Society)
NFPA - National Fire Protection Association
HMIS - Hazardous Materials Identification System
CFR - Code of Federal Regulations
SARA - Superfund Amendments and Reauthorization Act
DOT - US Department of Transportation
EC50 - Half maximal effective concentration
LD50 - Median lethal dose
LC50 - Median lethal concentration
SDS - Safety Data Sheet
   

 
Printable PDF of Safety Data Sheet